Product ID:DIESEL FUEL NO 1
MSDS Date:03/17/1990
FSC:9140
NIIN:00-286-5286
MSDS Number: BLXGR

CHEVRON ENVIRONMENTAL HEALTH CENTER INC.

15299 SAN PABLO AVE.
RICHMOND, CA 94804
US

Emergency Phone: 415-233-3737 OR 800-457-2022

Info Phone: 415-233-3737 OR 800-582-3835

Cage: 0AHD1

DELTA WESTERN

70438 SEATTLE, WA 98107 US

Telephone: 206-782-6977

Cage: 0NP88

ALIPHATIC PETROLEUM SOLVENT

CAS: 8008-20-6

RTECS: OA5500000

KEROSENE (HYDRODESULFURIZED)

CAS: 64742-81-0

DISTILLATES,STREIGHT RUN MIDDLE

CAS: 64741-44-2

RTECS: LX3296000

OSHA PEL 5 MG/M3 OIL MIST

ACGIH TLV: 5 MG/M3 OIL MIST

NAPHTHALENE (SARA III)

CAS: 91-20-3

RTECS: QJ0525000

Fraction By Weight: < 3.0%

OSHA PEL 10 PPM/15 STEL

ACGIH TLV: 10 PPM/15 STEL; 9192

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

LD50 LC50 Mixture:ORAL LD50 (RAT) IS > 5ML/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE-INHALED:IRRITATES RESPIRATORY
TRACT, HEADACHE,NAUSEA,DIZZINESS,LOSS OF APPETITE,WEAKNESS,LOSS OF
COORDINATION. EYES:IRRITATION.SKIN:PROLONGED/REPEATED CONTACT CAN
CAUSE PAIN,SWELLING, BLISTERING .INGESTION:MAY IRRITATE DIGESTIVE
TRACT.ASPIRATION INTO THE LUNG MAY CAUSE LUNG DAMAGE.CHRONIC-SKIN
DISCOLORATION,BLISTE
Explanation of Carcinogenicity:THE NIOSH HAS RECOMMENDED THAT WHOLE
DIESEL EXHAUST BE REGARDED AS POTENTIALLY CAUSING CANCER.
Effects of Overexposure:INHALATION CAUSES IRRITATION OF RESPIRATORY
TRACT, HEADACHE, NAUSEA, DIZZINESS, LOSS OF APPETITE, WEAKNESS, AND
LOSS OF COORDINATION. IRRITATES EYE. PROLONGED OR REPEATED SKIN
CONTACT CAN CAUSE PAIN, SWELLING, BLISTERING. INGESTION MAY
IRRITATE DIGESTIVE TRACT. ASPIRATION INTO THE LUNG MAY CAUSE LUNG
DAMAGE.
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH CONGENITAL
ERYTHROCYTE GLUCOSE-6-PHOSPHATE DEHYDROGENASE DEFICIENCY MAY BE
PARTICULARLY SUSCEPTIBLE TO THE HEMOLYTIC EFFECTS OF THE
NAPHTHALENE.

First Aid:GET MEDICAL CARE IN ALL CASES.INHALATION: REMOVE TO FRESH
AIR.PROVIDE CPR/OXYGEN IF NEEDED.EYE:FLUSH WITH WATER FOR 15
MINUTES KEEPING EYELID OPEN.SKIN:WASH WITH SOAP &
WATER.INGESTION:DO NOT INDUCE V OMITING.ASPIRATION HAZARD.IF
CONSCIOUS,DRINK MILK/WATER.CALL PHYSICIAN.IF SPONTANEOUS VOMITING
OCCURS,KEEP HEAD LOWER THAN HIPS TO PREVENT PULMONARY ASPIRATION.

Flash Point Method:TCC
Flash Point:100F,38C
Extinguishing Media:USE WATER FOG, CARBON DIOXIDE, FOAM, OR DRY
CHEMICAL. A FORCED STREAM OF WATER COULD SCATTER FLAMES OF FIRE.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:MAY FORM WATER VAPOR, CARBON MONOXIDE AND
CARBON DIOXIDE. WATER RUNOFF TO SEWER MAY CARRY COMBUSTIBLE FUELS &
CREATE A FIRE/EXPLOSION. MORE FIRE HAZARD IF >85F.

Spill Release Procedures:REMOVE SOURCE OF HEAT,SPARKS,FLAME,FRICTION &
ELECTRICITY,INCLUDING INTERNAL COMBUSTION ENGINE.USE
EXPLOSION-PROOF EQUIPMENT TO CLEAN UP.DIKE SPILL.PREVENT LIQUID
FROM ENTERING SEWERS, WATERWAYS/LOW A REAS.SOAK UP WITH
SAWDUST,SAND.SHOVEL/SWEEP UP.

Handling and Storage Precautions:STORAGE-STORE IN COOL,DRY
WELL-VENTILATED AREA IN CLOSED CONTAINER AWAY FROM HEAT,IGNITION
SOURCES & OXIDIZERS.
Other Precautions:COMBUSTIBLE LIQUID. USE WITH ADEQUATE VENTILATION.
AVOID CONTACT WITH EYES, SKIN AND CLOTHING. LAUNDER CONTAMINATED
CLOTHING BEFORE REUSE. GROUND AND BOUND CONTAINERS TO PREVENT
STATIC SPARKS. USE EXP LOSION-PROOF ELECTRICAL SERVICES.

Respiratory Protection:IN SITUATION WHERE VAPOR CONCENTRATIONS MAY
EXCEED THE RECOMMENDED EXPOSURE LIMITS, A NIOSH-APPROVED ORGANIC
VAPOR CARTRIDGE RESPIRATOR SHOULD BE WORN. USE SELF-CONTAINED
SUPPLIED-AIR RESPIRATOR FOR E MERGENCIES.
Ventilation:GENERAL DILUTION OR MECHANICAL VENTILATION/EXPLOSION-PROOF
LOCAL EXHAUST TO KEEP VAPOR BELOW RECOMMENDED EXPOSURE LIMITS
Protective Gloves:NEOPRENE, NITRILE, OR POLYVINYL ALCOHOL
Eye Protection:USE CHEMICAL SAFETY GOGGLES & FACESHIELD
Other Protective Equipment:EYE WASH STATION.BARRIER CREAMS SPECIFIC FOR
PETROLEUM-BASED MATERIALS MAY BE USED WHEN GLOVES ARE IMPRACTICAL.
Work Hygienic Practices:DO NOT TAKE INTERNALLY. AVOID SKIN CONTACT.
WASH SKIN AFTER USING PRODUCT. DO NOT EAT, DRINK OR SMOKE IN WORK
AREA.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATION, SEE P/N A SAME NSN. EMPTY
CONTAINERS MAY CONTAIN RESIDUE AND CAN BE DANGEROUS. DO NOT
PRESSURIZE, CUT, WELD, BRAZE, SOLDER, DRILL, GRIND OR EXPOSE TO
HEAT, F LAME; THEY MAY EXPLODE.

HCC:F4
Boiling Pt:B.P. Text:400F,204C
Spec Gravity:0.85
Solubility in Water:INSOLUBLE
Appearance and Odor:PALE YELLOW LIQUID WITH MILD PETROLEUM ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS CHLORATES, NITRATES, PEROXIDES, ETC.
Stability Condition to Avoid:HIGH HEAT, SPARKS, OPEN FLAMES AND OTHER
SOURCES OF IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE

Waste Disposal Methods:WASTE MAY BE BURNED IN AN APPROVED INCINERATOR.
TREATMENT, STORAGE, TRANSPORTATION AND DISPOSAL MUST BE IN
ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE AND FEDERAL LAWS AND
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.